RSS

Monthly Archives: April 2016

Bath Day…

 

Last week, before we changed his tailgate struts, we gave Old Red a bath. It had been a very long time since we’d had the chance to get him clean and he was looking rather green and very sorry for himself.

Not any more though!…thanks to…

…a handy husband (armed with a jet wash)…

20160413_155557sm

…a telescopic brush from Maplin (and a bucket of hot soapy water) note: this brush is cheap and *sort of* does the job. I don’t know if I’m just not strong enough to tighten it properly, but the brush head comes loose very easily. This is pretty annoying as it can cause you to give the paintwork a bit of a clunk, and you have to keep stopping to tighten it . It extends to 2m, which is great for reaching the top of the hi-top, and the brush handle plugs into a hose but Luke was already using our hose for the jet wash, so I made do with a bucket

20160413_161826sm

…and a helpful little sister (who had her first go at babywearing)…

20160413_164112sm

…we now have a shiny clean van who looks like someone loves him.

BeFunky Collage

Our wash and fix-up day also gave us the chance to give Old Red’s bodywork the once over, and we’ve been able to make a list of things that need to be looked at next. Things aren’t half as bad as I’ve been imagining they were, and despite the fact that Red has barely moved in so long (*cough* years *cough*) nothing seems to be drastically wrong (she wrote with crossed fingers).

The fact that Red has stood needing work for so long has been a constant weight on my mind, and seeing him looking more and more neglected as each day went by was a pretty depressing thing. In the past few days we’ve paid the old boy a lot of attention and not only is he looking better (happier, almost), but we’re feeling a lot better too.

20160414_110500sm

…it rained soon after we washed him…just our luck!…

 
Leave a comment

Posted by on April 20, 2016 in Van Maintenance

 

Tags: , , , ,

Tailgating…aka: Praise Be to VW Heritage…

20160413_163507sm

For as long as he has lived with us, Old Red’s tailgate struts (the bits that keep the boot hatch open) have been defunct and we have had to use brooms, planks, step-ladders and people to keep it open. This isn’t ideal as it makes access to the engine bay a little tricky, and also because the bike rack tends to drip cold water on whoever drew the “holding the boot open” short straw. So when I was asked to write a review for VW Heritage it really wasn’t difficult to think of a part that we needed.

Their website is organised by vehicle type, which makes finding parts for your bus or car a lot simpler…especially for people like me who don’t have as much experience with this kind of thing. There are also handy diagrams with a key so you can be doubly sure that you’re buying the right part. My lack of expertise made it hard for me to be certain of what I wanted (I mean, how can you search successfully for a tailgate strut if you think its real name is “boot propper-opener”?!) but all it took was a quick email to VW Heritage and I had all the help I needed.

There is also a ‘Live Chat’ feature on the website so, if you would rather open a speedy dialogue than draft an email, you have that option too.

Our parts – a pair of Meyle gas struts – arrived within days of ordering them.

It may have taken us six months to find a good day to get them fitted (I had overestimated just how much time I’d have to do van stuff once Velcro baby extraordinaire was here)…but get them fitted we did!

…finally…

So!

Removing the old struts…

This is obviously an excellent place to start.

Neither of us had much of an idea on how to do this job, so Luke had a look at the van while I had a look on Google. To say it’s an easy job would be a bit of an understatement, …he’d figured out what we needed to do (and started to do it) before the first page had even begun to load on my phone.

The struts are attached to the body of the van by a pin and a horseshoe clip (and two washers in the case of Old Red), and onto the tailgate by a ball joint with a pincer locking collar.

20160416_175657sm

…horseshoe clip and pin holding the strut to the body… (this is the cleaned clip and the new strut)

With the door propped up on a step-ladder (I don’t recommend using this method yourself as it wasn’t the safest…especially seeing as we kept walking into the ladder and dislodging it), we started by removing the struts from the body of the van.

To do this we used a flat screwdriver to push/slide/lever the horseshoe clip off the pin, freeing the end of the strut. Old Red’s clips had rusted into place but a few squirts of WD40 and some gentle taps with a hammer and screwdriver got them moving.

20160413_164728sm

The other end of the strut was even easier. You just slip your screwdriver into the back of the collar and lever it outwards to release the pincer hold around the ball stud so that you can pull it away.

20160413_165341sm

Et voila!…your strut is free.

…And on with the new…

Installing the new parts was just as simple.

Starting with the tailgate/ball joint end…you use your screwdriver to lever the collar open and hook the strut onto the ball stud.

20160413_165454sm

The collar locks securely around the ball, but we gave ours a good wiggle, just to be sure we’d done it correctly.

The other end slides back over the pin on the body…

20160413_165538sm

…and then you can replace the washers and clips (Luke cleaned ours before putting them back on) before standing back to admire your  handiwork.

20160413_165745sm

…done! Many thanks to Auntie Stephie for keeping her nephew happy while we worked…

It was such an easy job, and I just can’t explain how satisfying it is to not only have a working boot on our van (so satisfying that we opened and closed the boot many MANY times to test it out), but to actually have done it ourselves. Camping is going to be a whole new experience now, and doing work in the engine bay is going to be SO much easier…not to mention safer.

I’d like to offer a massive thank you to the guys at VW Heritage for their help in getting our first repair done. The struts are excellent quality and not only were they easy to fit, but they work superbly too. Our rear door is heavier than most (because of the huge, clunky bike rack) but it now opens and closes really smoothly, and (most importantly) it stays open without human intervention!

Now we’ve got one job off the to-do list, we’re keen to get on with more.

VW Heritage have a handy Wishlist function on their website that account holders can use to save items they want for future purchase (or in case a kind soul should want to buy you presents) so I’m going to use that to keep track of all the parts we need and want. With summer just a few weeks away we don’t have long to get Old Red back on the road, but I’m feeling really positive about our ability to get it done.

 

Tags: , , , , , , , , , , , , ,

 
%d bloggers like this: